Vol.:(0123456789)1 3 Photochemical & Photobiological Sciences (2022) 21:1701–1717 https://doi.org/10.1007/s43630-022-00252-w ORIGINAL PAPERS Development and characterisation of an irradiation device for biomedical studies covering the solar spectrum with individual regulated spectral bands B. Plitta‑Michalak1,4 · N. Stricker1 · E. Pavez Loriè2,5 · I. Chen3 · M. Pollet2 · J. Krutmann2 · B. Volkmer3 · R. Greinert3 · P. Boukamp2 · A. Rapp1  Received: 17 February 2022 / Accepted: 27 May 2022 / Published online: 24 June 2022 © The Author(s) 2022 Abstract To understand the importance of terrestrial solar exposure on human skin, not only individual spectral components need to be considered in biomedical studies, but also the relevance of the combined action profile of the complete solar spectrum (cSS) must be established. We therefore developed a novel irradiation device that combines the emission of four individual lamps (UVB, UVA, VIS and nIR) to achieve exposure from 280 to 1400 nm with individual controllable lamps. The inte- grated irradiance of each spectral band is similar to the solar spectrum. The lamps can be utilised individually or in any desired combination. Here we present the design, realisation, and validation of this irradiation device as well as biological results on cellular metabolism (MTT assay), cell cycle alterations, and clonogenic growth in HaCaT cells after exposures to the individual spectral bands as well as their simultaneous combinations. Thereby, we demonstrate that UVB combined with UVA is the main determinant for the metabolic activity within cSS. Also, UVB-dependent effects dominate cell cycle regulation in cSS, whilst UVA and nIR have little influence. Lastly, also clonogenic growth is dominated by the UVB action profile in cSS, despite nIR showing modulatory activity when applied in combination with UVB. Together, this highlights the regulatory influence of the different spectral bands on the three biological endpoints and demonstrates their modulation when being part of the complete solar spectrum. Graphical abstract Keywords  Solar UV radiation · Solar spectrum · Radiation device · MTT · Clonogenic survival · Combined irradiation · Cell cycle B. Plitta-Michalak and N. Stricker contributed equally. * A. Rapp rapp@bio.tu-darmstadt.de Extended author information available on the last page of the article http://orcid.org/0000-0001-9108-3929 http://crossmark.crossref.org/dialog/?doi=10.1007/s43630-022-00252-w&domain=pdf 1702 Photochemical & Photobiological Sciences (2022) 21:1701–1717 1 3 1  Introduction Although there exists overwhelming evidence that UV radiation (280–400 nm), reaching the surface of the earth, is the most important risk factor for skin cancer initiation, the contribution of the different wavelength regions (UVB: 280–315 nm, UVA: 315 − 400 nm) to this development is still poorly understood. Additionally, it is unclear whether the other components of optical radiation, emitted from the sun (visible light (Vis) and near-infrared radiation (nIR)) act synergistically (additively) or, eventually, even in a compen- satory way. Indeed, there is no scientific evidence stating that UV exposure is exclusively responsible for skin dam- age [1]. The historical wavelength bands definitions are not directly related to biological effects, which show a continu- ous transition. Therefore, this issue needs to be addressed for a correct risk estimation and assessment of terrestrial solar radiation impact on biological systems, as optical radiation qualities are always delivered simultaneously. Experimental evaluations of the exposure of humans and cultured cell lines to solar radiation have been undertaken for many years. These studies were either performed using indi- vidual spectral regions in the UVB or UVA range [2–6] or solar spectrum simulator radiation (SSR) devices were used [7, 8]. The majority of studies using SSR is based on xenon lamps combined with spectral filters to adapt the emission to the solar reference spectrum (air mass filters) [9–11]. The solar spectrum can be mimicked to a good extent (e.g. 0.875–1.125 spectral match in Class A + SSR devices) in a spectral range from 280 to 800 nm and an irradiance of several solar equivalents can be achieved, for studying, e.g. photo-ageing or skin cancer [12]. However, most of devices share the disadvantage of limited emission and missing the typical water absorption bands in the nIR spectral range [13]. Furthermore, the xenon-based SSR devices often have a size-limited homogeneous irradiation area and produce an excessive amount of heat. Recent technological improve- ments have led to the development of LED-based SSRs [14, 15]. These devices use a combination of individually tuned narrow-banded LEDs to mimic the solar spectrum. Yet, the LED-based SSRs also have some limitations. One impor- tant drawback is the low irradiance in the UV (B) and nIR range, due to design limits in the LED substrates. Especially, wavelengths greater than 1100 nm are under-represented and mostly, only the visible spectrum is matched to the refer- ence solar spectrum. Moreover, to perform wavelength-spe- cific exposure (e.g. in the UV wavelength band), the SSR spectrum requires additional filtering, e.g. UG1 filters are introduced to block the visible light spectral components (400–700 nm). Whilst in conventional SSRs, the spectrum is fixed and can only be altered using specific filters for each specific condition, a device allowing for spectral band-specific irradiation would be desirable. This would allow mim- icking different exposure conditions more easily, such as geographical location, ozone layer conditions, season, and effects of sunscreens on different wavelength bands. Besides improving the area of application, such a device would be suited to also address fundamental radiation bio- logical questions. Accordingly, it is well accepted, and there is ample literature [16–19] reviewed in [20], that the indi- vidual spectral bands exhibit different efficacy to induce cer- tain biological effects (e.g. differences in the action spectra for UVB and UVA). In addition, evidence is emerging that the combinations of different spectral bands (e.g. UVB plus UVA, or UVB plus nIR exposure) lead to different biological effects that are not purely additive [21–25]. Therefore, an SSR with tunable spectral bands would be most instrumental for the understanding of solar exposure [26–28]. Here, we describe an SSR that is based on four individual lamps/tubes for the four spectral bands (UVB, UVA, VIS, and nIR), and importantly, which are individually control- lable. With biological proof-of-principle experiments, we demonstrate the relevance and practicability of this radiation device, thereby providing first evidence that the combined spectrum (from UVB to nIR) introduces qualitatively and quantitatively different biological effects compared to the different individual wavelength bands. 2 � Materials and methods 2.1 � Irradiation device In contrast to existing irradiation sources, where the emis- sion of a single lamp is filtered by appropriate filters [12], the new irradiation device used an additive approach. The part of the solar spectrum in the range of 280–1400 nm is generated by four lamps and combined with dichroic beam combiners onto the sample. Optical filters and dichroic beam combiners control the spectral ranges of the indi- vidual lamps. In addition, each lamp is electrically inde- pendently switchable and the UVA, UVB, and nIR lamps can be attenuated by specific filters (optical and metal mesh filters) in the corresponding filter sliders. The infrared lamp is additionally filtered by an actively cooled water cuvette and a near-IR-specific band pass filter. The construction of the irradiation device based on four individually controllable lamps is described in detail in the results section. In brief, the cells were irradiated with the following photo-physical conditions: the irradiation area has a size of 17 by 17 cm and thus allows to irradiate five p60 dishes or two 6-well plates simultaneously. The complete base plate of the irradiation device is temperature controlled by Peltier elements to keep the temperature constant. 1703Photochemical & Photobiological Sciences (2022) 21:1701–1717 1 3 The standard exposure setting as used in this study pro- vides 0.36 kJ/m2 UVB, 27.5 kJ/m2 UVA, 129 kJ/m2 VIS and 150 kJ/m2 nIR in approximately 560–630 s, depending on actual lamp output. From these values, the irradiance can be calculated to be approximately 0.64 W/m2 (UVB), 42 W/ m2 (UVA), 120 W/m2 (VIS) and 220 W/m2 (nIR), respec- tively. The irradiance is measured before each exposure, and the exposure times are adjusted accordingly to compensate, e.g. for lamp ageing. This is achieved by a built-in CCD array spectrometer (Model LR1, Aseq Instruments, Canada), which is fibre-coupled (SMA905) to a cosine adapter located at the centre of the irradiation chamber base plate. This spec- trometer allows for every day calibration and compensation of lamp ageing or changes in the spectral composition of the irradiation device. The installed spectrometers were cali- brated against a BN 9101 reference lamp (Gigahertz-Optik, Germany) by Photometrik GmbH (Germany). All photomet- ric calculations are performed using a home-made graphical user interface (Processing (www.​proce​ssing.​org)) and the hardware components are controlled through an Arduino micro-computer capable of switching the individual lamps. For each radiation experiment, the user records the actual/ current emission spectrum of the lamps using the Aseq soft- ware and loads the spectrum into the lamp control software. After providing the set exposure time, the software uses the stored calibration file for the Aseq spectrometer to convert the counts to doses. Then the user sets the desired exposure conditions for each spectral waveband individually and starts the exposure. After the calculated times have been reached, the Arduino microcontroller automatically switches off the respective lamp. An example of the user interface is given in supplementary materials S2. 2.2 � Cell culture HaCaT cells [29] (distributed by CLS Cell lines Service # 300493) were grown in DMEM (4.5 g/L Glucose, L-Glu- tamine, Sodium pyruvate, 3.7 g/L NaHCO3) (Pan Biotech) containing 10% FBS (Capricorn) and 0.1% Pen/Strep (Pan Biotech) at 37 °C in the presence of 5% CO2. For irradia- tion, the culture medium was replaced by prewarmed PBS and directly after irradiation, the PBS was changed again to complete culture medium. For cell harvest, HaCaT cells were treated with PBS/EDTA (1 mM) for 2 min followed by Trypsin/EDTA (0.5%/0.2%) for 10 min. Enzymatic activ- ity was stopped by adding 5 mL culture medium and after centrifugation (5 min, 200 g) the single cell suspension was available for further analysis. 2.3 � Irradiation Cells were seeded as described for the individual experi- ments. The culture medium was replaced by pre-warmed PBS and the cells were irradiated with the indicated doses and spectral combinations. During irradiation (between 10 and 42 min), the temperature of the cells was kept constant at 36 °C by the built-in Peltier element. Temperature was confirmed for several irradiation experiments using a digital temperature probe inserted into the PBS. No significant tem- perature change was measured during the time of irradiation. Mock-irradiated samples were transferred to PBS and placed inside the irradiation device, but covered in aluminium foil for the same time as the exposed samples. Exposed samples were normalised to the mock-irradiated controls. 2.4 � Flow‑cytometric quantification of cyclobutane pyrimidine dimers (CPDs) To compare the biological effects of four similar irradiation devices, located in four different laboratories, we performed a ring trial, relying on flow cytometry-based quantification of UVB and UVA-induced cyclobutane dimers (CPDs). For this, HaCaT cells were irradiated in the individual labs with their respective irradiation devices with increasing doses of UVB (120–288 J/m2) as well as with one dose of UVA (22 kJ/m2) and CPD induction was measured in the reference laboratory for all samples simultaneously. For each measurement, 5 × 105 HaCaT cells were seeded in 60 mm Petri dishes and grown under standard conditions (see above). Cells (in PBS) were exposed to different doses of UVB and UVA at a confluence of 80–90%. Immediately after irradiation, the cells were harvested. The single cells were fixed in 70% ethanol by drop-wise addition to a con- centration of 1 × 106 cells/mL and incubated at − 20 °C for at least 1 h. Next, 2.5 × 105 cells were permeabilized for 10 min at RT in 1 × blocking and washing solution (Roti®Block, Carl, Roth) with 0.125% Triton X-100. For DNA denatura- tion, cells were re-suspended in 2 N HCl (Carl Roth) for 10 min at RT followed by a 10 min incubation with 5 µg/mL proteinase K (Sigma) at 37 °C. Cells were incubated with 1 µg/mL mouse anti-CPD antibody (clone KTM53, Kamiya Biomedical Company) overnight at 4 °C. On the next day, cells were incubated with 15 µg/mL goat anti-mouse FITC- conjugated antibody (Dianova) for 1 h at 37 °C and after- wards incubated for 5 min at RT with 10 µg/mL propidium iodide and 0.01% RNase (both from Sigma) prior to meas- urement with Guava easyCyte 8HT Flow cytometer (Merck). 2.5 � MTT assay To measure cellular metabolism using the MTT assay [30], 1 × 104 HaCaT cells were seeded per well in 4-well plates (2 cm2 growth area; SPL Life Sciences). Cells were irradi- ated (in PBS) as indicated in the results section and cul- tured for the indicated times in regular growth media. Cor- responding controls were kept in PBS for the same time as http://www.processing.org 1704 Photochemical & Photobiological Sciences (2022) 21:1701–1717 1 3 the irradiated samples. At the time of analysis, the medium was removed and the cells were washed carefully in pre- warmed PBS. Then 1 mL fresh complete culture medium, including MTT at a final concentration of 0.5 mg/mL, was added and the cells were incubated for 2 h at 37 °C. Then 250 µL DMSO were added per well and the formazan was dissolved by shaking on an orbital shaker for 10 min at RT, protected from light. Reduced MTT was measured by absorbance at 590 nm with a reference at 620 nm using a Tecan Infinity M200 plate reader in duplicates per well (technical replicates), and quadruplicates (biological rep- licates) per condition, resulting in eight measurements per sample. The measurements were normalised to the cor- responding control cells. 2.6 � Cell cycle analysis Cell cycle distribution in HaCaT cells following a single exposure as indicated in the results section to individual and combined spectral band irradiation was measured by flow cytometry. For these experiments, we choose a single set of doses (0.36 kJ/m2 UVB, 27.5 kJ/m2 UVA, 129 kJ/ m2 VIS and 150 kJ/m2 nIR), to avoid extensive cell killing (compare Figs. 5A–D). We also omitted VIS exposure on the cell cycle regulation since we did not observe signifi- cant effects of VIS in the MTT assay. Cells were seeded in 60 mm dishes and grown to 20% confluency. Then, the cells were irradiated in PBS, fresh culture medium was added and incubated for the indicated times using standard conditions. Thereafter, the cells were harvested by trypsinization and fixed by adding the cell suspension drop-wise into 4.5 mL of ice-cold 70% ethanol. Cells were fixed for at least 2 h at 4 °C. For quantitative DNA staining, the fixed cells were centrifuged (200g, 5 min) and re-suspension in propidium iodide staining solution (0.1% Triton X-100, 0.2 mg/mL RNase A 20 µg/mL pro- pidium iodide in PBS). Cells were incubated at RT for 30 min, followed by overnight incubation at 4 °C, before the cells were analysed for their DNA content using a S3 cell sorter (Biorad) with 488 nm excitation and 615/25 nm emission filters. Cell cycle distributions were quantified using FlowJo (version 10) after doublet discrimination and gating (the gating strategy is depicted in Figure S4) using the Dean–Jett–Fox algorithm. A minimum of four biological replicates were measured per irradiation condi- tion and time point (minimum of 10,000 cells per sample). Statistical testing was performed using one-way ANOVA test. Individual measurements for each irradiation con- dition and time point were compared for each fitted cell cycle phase to the control measurements separately. Post analysis using Dunnett’s post test with a significance level of 0.05 was used. Significance levels are indicated using * as described in the figure legend. 2.7 � Colony formation assay Five hundred HaCaT cells were seeded in a 60 mm Petri dish (24 cells/cm2) and cultured overnight at 37 °C. For irra- diation, the medium was exchanged to PBS and the cells were irradiated with the indicated spectral bands and doses. Thereafter, the PBS was replaced with culture medium and the cells were incubated for 9 days at 37 °C under standard conditions. Then cells were fixed with 5 mL ice-cold metha- nol (100%) for 5 min, washed twice with PBS and stained with 5 mL 0.2% methylene blue in methanol (50%) for 10 min at RT. After three washings with ddH2O, the colonies in all individual dishes were counted. Examples of stained colonies are shown in Figure S5. As controlled microscopi- cally, a colony of cells was defined as a cluster of at least 50 normal-sized cells, thereby excluding significant contri- bution of giant or large multi-nucleated cells. Quantitative analysis of colonies was performed after recoding images of the plates (Amersham AI600 imager) using imageJ. In brief, the images were cropped to the individual dishes, “Auto- threshold (Max Entropy)” was applied and a mask was gen- erated. The mask was processed with a watershed algorithm to separate touching colonies. Then the “Analyze Particles” function was used with the following settings: size: 10–500 pixels, circularity: 0.1–1.0. The results of the automated counted were inspected manually and false detection was corrected. At least four biological replicates were analysed per irradiation condition. The dose–response curves were generated using a linear regression model. Significance of slopes to be non-zero was calculated using F-statistics. Col- ony sizes were compared using one-way ANOVA test with Bonferroni post test. Colony sizes from one measurement were compared to the matching control. A significance level of 0.05 was used. 3 � Results 3.1 � Design and construction of a solar spectrum irradiator based on four separate lamps For the combinatorial irradiation device, the following lamps were chosen: Philips PL-S 9W/12 2P UVB broadband tubes for the UVB range, Philips Cleo high-pressure lamp for the UVA spectral band, and Osram Xenon high-pressure short arc lamp XBO R 300 W/60C OFR for the visible spectrum. For the nIR range, a GE Healthcare 750 W Halogen lamp HPL 750 W LL 240 V was integrated (Fig. 1A). All lamps were equipped with additional reflectors to maximise light output. 1705Photochemical & Photobiological Sciences (2022) 21:1701–1717 1 3 Fig. 1   A Schematic set-up of the irradiation device depicting the placement of the four lamps as well as the beam combiners and (optional) filters for the individual lamps. B Raw spectrum of the four individual lamps in relation to the ASTM G173 reference spectrum without additional optical or density filters, except for the IR spec- trum, which is already filtered by the 2  cm water cuvette and the Solaris IR S306 filter. Y-axis in log scale. C and D Further filtering with long- and short-pass filters of the UVB and UVA lamps ensure the minimal spectral cross-contamination from one lamp to the other spectral bands. Additionally, the UVB tubes were filtered to ensure there is no detectable light below 280  nm, due to the high biologi- cal activity and unphysiological occurrence of these wavelengths. The shaded areas indicate the targeted spectral ranges for the indicated lamp 1706 Photochemical & Photobiological Sciences (2022) 21:1701–1717 1 3 The emitted light from the four lamps was combined by three beam combiners (dichroic mirrors). First, a custom- made 315 nm (45°) beam combiner (S1 Optics, Germany) added the emission of the UVB lamps to the total spectrum. Second, a custom-designed 400 nm (45°) beam combiner (S1 Optics, Germany) was installed to add the UVA range. Third, a 750 nm (45°) cold mirror (Knight Optical) was used for the addition of the visible spectrum. The beam combin- ers dictated the positioning of the lamps. Since only short wavelength light can be reflected and long wavelength light passes through the dichroic mirrors, the UVB source had to be positioned closest to the sample area, whilst the infrared emitting lamp needed to be positioned with the greatest dis- tance. The HPL 750 W LL lamp, used for the infrared part of the combined spectrum, was filtered by a 2 cm cooled water cuvette and a 750 nm long-pass filter (Solaris IR S306, PSC, Denmark). After the first assembly, we measured the spectral irradiance of the individual lamps as well as the combined irradiation (Fig. 1B) using a Spectro320-166 (Instrument Systems, Germany) spectrometer calibrated against a BN 9101 reference lamp (Gigahertz-Optik, Germany) in the range of 250–2800 nm. Based on these results, further modi- fications were implemented: the UVA lamp was filtered by a long-pass Schott WG 320 filter to prevent cross-contamina- tion of the UVB spectrum with small amounts of UVB emit- ted from the UVA lamp. The UVB lamp was filtered with an Asahi Spectra UV325 short-pass filter (ZUS0325, Mountain Photonics, Germany). This filter blocked the emission of UVA from the UVB lamps. Additionally, a UVB long-pass filter (Schott B270, Reichmann Feinoptik, Germany) was used to filter out any UVC radiation. With this set-up, the spectral emissions of the UVA and UVB lamps were largely restricted to the targeted spectral bands (Fig. 1C and D, as well as Table 1). One exception was the emission of visible light by both the UVA and UVB lamp. When compared to the normal environmental irradiance, however, the absolute values of visible light in this setting were still low (24% of ASTM G173). Further adjustments refer to incorporating metal mesh filters with defined open apertures in front of the UVA and UVB lamps to achieve the desired ratio of UVA to UVB as well as irradiance similar to the ASTM G173 reference spectrum [31]. With these modifications, the resulting irradi- ance for the UVB and UVA spectral range was measured to be 0.64 ± 0.05 W/m2 (UVB) and 41.6 ± 0.86 W/m2 (UVA), respectively, corresponding to 94% and 91% of the ASTM G173 reference spectrum and a UVA to UVB ratio of 1:64 (close to the calculated ratio of 1:66 in the ASTM G173 ref- erence spectrum). As mentioned above, the visible spectral range (400–750 nm) is under-represented and only reaches approximately 24% of integrated irradiance of the ASTM G173 reference spectrum (see above), whilst the near-infra- red range had an irradiance of approximately 62% of the reference spectrum. All details are listed in Table 2. To prevent nIR-related overheating, we integrated an actively cooled water filter, which efficiently reduces the thermal effects of IR irradiation. An external laboratory chiller pumps precooled water (11 °C) through the 2 cm infrared filter cuvette. The same chiller was used to cool Peltier elements, which in turn control the temperature of the irradiation chamber base plate (copper). 3.2 � Physical validation of the irradiation devices After final assembly of four identical irradiation devices, we performed several irradiation tests for the reproducibil- ity and stability of the lamps. First, we analysed the homo- geneity of the irradiated area (17 cm × 17 cm) by placing Table 1   Spectral cross- contamination after additional filtering of the UVA and UVB lamps The measured irradiance of each spectral band in four identically built devices was averaged and normal- ised to the irradiance in the targeted spectral band (100%, indicated in the column headers). Errors indicate the standard deviation. The numbers represent the percentage irradiance emitted in each band normalised to the irradiance in the targeted spectral band UVB band (280–315 nm) UVA band (316–400 nm) Vis band (401–750 nm) IR band (751–1400 nm) UVB lamp 100 ± 0 68 ± 6.27 132.93 ± 13.07 22.87 ± 7.41 UVA lamp 0.01 ± 0.01 100 ± 0 68.04 ± 6.92 11.53 ± 2.9 VIS lamp 0 ± 0 1.34 ± 0.38 100 ± 0 9.04 ± 1.13 IR lamp 0 ± 0 0 ± 0 0.29 ± 0.19 100 ± 0 Table 2   Irradiance in four spectral bands (percentage of ASTM G173 reference in brackets) Values present the average of four identically built devices and errors represent the standard deviation (compare to Figure S1C) UVB (280–315 nm) UVA (316–400 nm) Vis (401–750 nm) IR (751–1400 nm) Irradiance [W m−2] 0.64 ± 0.05 (94%) 41.6 ± 0.86 (91%) 119 ± 12.4(24%) 218 ± 12.2(62%) 1707Photochemical & Photobiological Sciences (2022) 21:1701–1717 1 3 the measurement head of a calibrated portable spectrom- eter (Jeti specbos 1211UV, JETI Technische Instrumente, Germany) at 16 sites regularly spaced across the irradiation sample area (4 cm distance each in x and y directions) and measured the individual and total spectral emission (in the range of 250–1200 nm) of the irradiation devices. The irradi- ance variations between the different locations were found to be < 10%, except for three positions at the border, which showed variations of 11 and 12%, respectively (Figure S1A). These measurements were taken at the extreme edges of the sample area, locations that are rarely used in the experiments described in this study. Next, we assessed the temporal sta- bility of the four irradiation devices by measuring the same position (central on the sample area) repeatedly (6 × over a time period of 1 h). The variations in the total integrated irradiance (270–1000 nm) were found to be < 10% in all four built devices, demonstrating stable irradiation condi- tions (Fig. S1B). The average spectra of all four lamps were measured in the range from 250 to 1000 nm (Jeti specbos) at the same 16 positions in the sample area. Figure S1C shows the com- parison of the four irradiation devices, indicating the repro- ducibility of the set-up and the spectral similarities. The largest variations were found in the visible spectral range (400–750 nm) with a coefficient of variation of 0.236 in con- trast to the lower values found for the other spectral ranges: 0.065 (UVB), 0.057 (UVA) and 0.039 (nIR) respectively (see also Figure S1A). For a more biological relevant com- parison, we performed a weighting of the raw spectral data with the CIE erythema action spectrum [32] (Fig. S1D). The integrated CIE-weighted UVB irradiance of the developed device was measured to be 0.177 W/m2 and therefore higher than the ASTM G173 (0.051 W/m2) due to the cut-off of the ASTM G173 at 290 nm. This cut-off varies in natural conditions and is higher in the ASTM G173 spectrum [33]. In contrast, the integrated CIE-weighted irradiance in the UVA range was identical (0.039 versus 0.034 W/m2), for the AMST G173 spectrum and our device, respectively. 3.3 � Comparability and consistency of four versions of the irradiation devices: biological validation of the radiation efficacy In a ring trial, the CPD induction by the four build devices was measured after immuno-staining in a flow cytometer. The dose-dependent formation of CPDs is shown in Fig. 2 for each device individually with the indicated lamps acti- vated and demonstrates that there were no significant dif- ferences between the four dose–response curves (one-way ANOVA with Bonferroni’s post hoc test). In addition, we measured the CPD generation after exposure to UVA. We detected UVA-induced CPDs after identical exposure times required for 288 J/m2 UVB corresponding to 22 kJ/m2 UVA. This exposure resulted in significantly higher CPD levels compared to controls, but approximately tenfold lower lev- els compared to 288 J/m2 UVB. Considering the different radiant exposure values (doses), the CPD induction rate was ~ 750-fold lower for the UVA exposure compared to the UVB exposure, and close to values reported earlier [34, 35]. 3.4 � Cellular metabolic activity as measured by MTT HaCaT cells were exposed to single spectral bands as well as combinations thereof. The 0.36 kJ/m2 UVB exposure corresponds according to [32] to an exposure of 4.6 min in mid-summer or approximately 53 min in winter (using Lauder, New Zealand as a reference measurement station (45°S, 170°E, altitude 370 m)). For the UVA range, the cor- responding exposure times would represent 6.6 min in sum- mer and 22 min in winter. UVB exposure resulted in a significant dose- and time- dependent decrease in metabolic activity (based on the linear regression of the dose vs. the half-life time constant), detect- able 24 h post irradiation (Figs. 3A and S3A). This decrease was on-going up to 72 h. The decrease in metabolic activity following all exposures was directly dependent on the dose and could therefore be fitted with a linear regression (Fig- ure S3). For UVA exposure, we found a time-dependent, non-significant decrease in metabolic activity. This was only observed at doses above 82.5 kJ/m2. Visible and nIR expo- sure did not result in a significant reduction of metabolic activity (Figs. 3C, D and S3C, D). When UVB and nIR irradiation was applied simultane- ously, the significant reduction in metabolic activity was Fig. 2   Induction of CPDs by the four identically built irradiation devices. Shown are the relative intensity levels per cell detected by flow cytometry, after UVB exposure with the indicated doses and immune-fluorescence detection of CPDs. Plotted are the mean values of at least three biological replicates after subtraction of the fluores- cence intensities of the control cells together with the standard error of the mean. Dose–response curves were linearly fitted. On the right, the levels of CPDs after UVA exposure are plotted 1708 Photochemical & Photobiological Sciences (2022) 21:1701–1717 1 3 similar to the reduction observed for cells exposed to UVB only (Fig. 3E and S3E). Simultaneous exposure to UVA and nIR did not show a significant effect at lower doses (27.5 kJ/ m2 UVA + 150 kJ/m2 nIR and 55 + 300 kJ/m2 nIR) and led to a non-significant reduction in metabolic activity at higher doses, mainly at day 2 and 3 (Figs. 3F and S3F). In contrast, when UVA and UVB were applied simultaneously, meta- bolic activity decreased significantly stronger (smaller half- life time) than for individually applied UVA or UVB (up to 1.5-fold). The dose-dependent decrease in metabolic activity occurred directly after irradiation and the trend was persis- tent, although not significant, at day 1 and 2 after exposure to simultaneous UVA and UVB radiation (Figs. 3H and S3H). Irradiation with the full spectrum caused the same toxic profile as the combination of UVA and UVB, demonstrating that VIS and nIR did not modulate the cells’ metabolic activ- ity when combined with UVA and UVB. The main differ- ence between UVA + UVB exposure compared to the com- plete spectrum is the metabolic activity seen at the first and second time point. There, the complete spectrum reduced the metabolic activity even stronger (not significant) than in the UVA + UVB exposed cells, although VIS and nIR alone do not show any negative effect on cell metabolism (Fig. 3H). 3.5 � Cell cycle modulation of combined spectral bands Next, we asked whether the different irradiation regimes would affect the cell cycle of the surviving cells. UVB expo- sure led to the most pronounced biological response. As an early effect 2 h post irradiation—UVB induced a significant G1 arrest followed by a significant S-phase increase 12–16 h after exposure (Fig. 4A) as also reported in [36]. After that, a significant increased G2/M fraction was detected (18 h). Then the cell cycle distribution started to return back to nor- mal levels. UVA exposure with 27.5 kJ/m2 showed less-pro- nounced cell cycle alterations with as significant increase in S-phase cells directly after exposure up to 2 h post exposure Fig. 3   Metabolic cellular activity was assessed using the MTT assay directly after irradiation (day 0) and 24 h, 48 h, and 72 h post irra- diation for individual spectral bands UVB (A), UVA (B), VIS (C) and nIR (D). Additionally combinations of spectral bands were ana- lysed: UVB+nIR (E), UVA+nIR (F), UVB+UVA (G) as well as the complete spectrum (H). Each condition/dose was at least measured in three biological replicates with two technical replicates each and normalised to the corresponding sham-irradiated control. The plotted values represent the means of the replicates together with the stand- ard error of mean. Doses are represented in different grey levels and the resulting data points were fitted using a one-phase decay function. Statistical significance of the different decay curves was estimated based on the half-life fitting parameter and its corresponding 95% confidence interval (CI). In cases where the CI did not overlap (pair- wise analysis), the one-phase decay curves were assigned significant difference (*) based on a p value of 0.05. The dose-dependent curves for each day are shown in Figure S3 1709Photochemical & Photobiological Sciences (2022) 21:1701–1717 1 3 (Fig. 4B). A significant increase in S-phase cells was found 12 h and a significant reduction of S-phase cells at 72 h post exposure. After nIR irradiation, we only observed a signifi- cant increase of S-phase cells directly after exposure. All other tested time points did not show significant changes in the cell cycle distribution (Fig. 4C). When UVB was simultaneously applied with nIR, the significant S-phase arrest at 12 h post irradiation was found similar to the arrest seen with UVB alone (Fig. 4A and D). Interestingly, the initial G1 arrest (2–4 h post irradiation) was not detectable in the co-exposed cells (UVB + nIR) and the subsequent release was faster in UVB + nIR exposed cells compared to UVB exposed cells alone. UVB and UVA co-exposed cells showed the most pronounced cell cycle alterations with an extended significant S-phase arrest already 8 h post irradiation and lasting until 12 h. This exposure condition also induced the early G1 arrest (directly after exposure). The late G1 arrest (72 h) was commonly found (Fig. 4B, E and F) in UVA, UVA + nIR and UVA + UVB exposed cells. When UVA was combined with nIR, we found a smaller, but sig- nificant S-phase arrest 18–24 h post irradiation. This arrest was stronger when compared to the individual irradiations or the additive effect thereof (Fig. 4B and E). Most nota- bly, when the full spectrum (UVB + UVA + VIS + nIR) was applied, the cell cycle distribution resembles that of Fig. 4   Cell cycle distribution of HaCaT cells after exposure to indi- vidual spectral components (A–C) and combinations thereof (D–G). Cells were harvested at the indicated times and analysed using flow cytometry. The cell cycle distributions were calculated based on the quantification of the DNA content after propidium iodide staining and then fitted, using the Dean–Jett–Fox algorithm (FlowJo). An example workflow, including the gating steps is shown in Figure S4. The bars represent the average percentage of cells assigned to the correspond- ing cell cycle phases and are based on at least 4 biological replicates per dose and condition. The error bars represent the standard error of the mean. The cell cycle distribution of control cells is shown at the left of each subplot and the G1, S and G2 fractions are shown as dot- ted lines. Significance was tested against the control for G1, S and G2 populations individually. *p ≤ 0.05; **p ≤ 0.01; ***p ≤ 0.001 1710 Photochemical & Photobiological Sciences (2022) 21:1701–1717 1 3 UVB only, with the S-phase arrest at 12 h post exposure as the predominant effect (Fig. 4G) and no significant late G1 arrest. Taken together, we can conclude that the cell cycle is significantly affected by UVB exposure (0.36 kJ/m2). Co- exposure with UVA (27.5 kJ/m2) or nIR (150 kJ/m2) exerts some modulation; however, as part of the entire solar spec- trum, these effects do not seem to become effective. 3.6 � Clonogenic survival of UVB exposure is modulated by co‑exposure with both UVA and nIR Finally, we asked whether and how the above-identified early effects would impact on the long-term growth capacity of the HaCaT cells. To address this, we per- formed clonogenic survival (or colony forming) assays. First, we produced dose-dependent survival curves for the individual spectral bands (UVA, UVB and nIR). Whilst UVB exposure (120–720 J/m2) resulted in a significant Fig. 5   Clonogenic survival obtained from irradiated HaCaT cells. Depicted are the colony formation results for individual spectral bands (A–D) as well as for irradiation with combined spectral bands (E–I). The impact of each irradiation treatment was measured at least in three biological replicates and normalised to the corresponding sham-irradiated control. The plotted values represent the means of the replicates, together with the standard error of mean. The doses for each individual or combined exposure are given at the x-axis. Linear curves were fitted (grey lines). Examples of the colonies are shown in Figure S3. Statistical testing whether the fitted linear slopes are sig- nificantly different from zero revealed significance for A, E, G, H and I  1711Photochemical & Photobiological Sciences (2022) 21:1701–1717 1 3 linear dose-dependent reduction in colony number with − 10.66 ± 1.48% per 100 J/m2, UVA (9.2–55 kJ/m2), VIS (0–258 kJ/m2) and nIR exposure (0–300 kJ/m2) did not cause significant linear relationship between dose and reduction in colony formation (− 18.73 ± 7.4% per 100 kJ/ m2, − 2.75 ± 2.14% per 100 kJ/m2 and − 1.7 ± 1.8% per 100 kJ/m2 respectively) (Fig. 5 A-D). When UVB was combined with nIR, the cytotoxic effect was signifi- cantly increased as compared to UVB irradiation alone (Fig. 5E vs. 5A and S5). The dose-dependent reduction in colony formation increased from − 10.66 ± 1.48% to − 13.22 ± 1.65% per 100 J/m2. This additive cytotoxic effect was not seen upon simultaneous irradiation of UVA and nIR (Fig. 5B vs. F), where the dose–effect curves had similar slopes (− 18.73 and − 18.53% per 100 kJ/ m2). Interestingly, when UVA was simultaneously applied with UVB, the cytotoxic effect of UVB was mildly, but significantly reduced (Fig. 5A vs. B vs. G) from − 10.66 to − 7.35% per 100 J/m2. When we combined three or all four spectral bands, we found a cytotoxic effect similar to that of UVB alone (Fig. 5A vs. H). 3.7 � Proliferative expansion (colony size) is influenced by UVB As an additional parameter for the radiation effect on long-term cell survival, we analysed the resulting colony sizes in the clonogenic survival assay. Whilst nIR expo- sure did not modulate growth of the HaCaT cells, UVA decreased the colony size significant for doses of 27.5 and 36.7 kJ/m2. UVB caused a significant increase in colony size with low-dose radiation 0.12 kJ/m2 (Fig. 6) and a dose-dependent decrease at higher doses (0.48 and 0.72 kJ/m2). When UVA and UVB irradiation was combined, a sig- nificant decrease in colony size was seen for all doses. Accordingly, most prominent changes in colony size dis- tribution were only seen upon radiation with combinations including UVB. With UVA + B as well as UVB + nIR, the primary increase in colony size was lost, compared to UVB exposure alone and the overall decrease in colony size was attenuated, demonstrating a modulatory effect upon combination. As part of the entire spectrum, how- ever, the UVB effect was dominant with an increase at the lowest dose and decline of the colony size thereaf- ter, although these observations are not significant due to the large size variations of the individual measurements. Again, this demonstrates that in combination, the individ- ual wavelengths act differently, i.e. do not exert a defined action spectrum but rather the combination of wavelengths determines their individual contribution in modulating cel- lular events. 4 � Discussion Solar radiation and in particular solar UV radiation is of outmost importance, not least, because of its contribu- tion to skin ageing and skin cancer. Accordingly, there is a longstanding interest in the role of UVB and UVA [1, 37]. More recently, also IR and VIS gained interest and were investigated more extensively concerning their contribution to cellular damage [24, 38–41]. However, the effect of the solar spectrum (ss) with all its wavelength combinations, is not well understood and is likely far more complex than the combined (additive) action of all individual wavelengths. Consequently, questions have arisen about the combined exposure to UVR (UVB and UVA) IR, and VIS and their intracellular action spectrum, i.e. whether additive/syner- gistic or even modulatory/antagonistic interactions occur. Concerning the biological action spectrum, it was shown that all four wavelengths (UVB, UVA, VIS, and IR) induce ROS in skin cells (Zastrow et al. [18] and references therein) and besides inducing different rates of ROS, the different wavelengths may do so through non-overlapping mecha- nisms. To become effective however, the ROS level has to exceed the physiological range in a certain time period. Therefore, it is further suggested that all spectral bands may act in an additive/synergistic way when being applied to skin cells simultaneously, i.e. through the solar spectrum. How- ever, a clear interactive role is still elusive. All this demonstrates that the comparison of single and combined radiation qualities (different wavelength combinations) is essential and requires further investiga- tion. The studies, however, also indicate that the technical requirements for respective studies are still insufficient. Frequently, irradiation devices only allow for a restricted set of simultaneous combinations [42–44], or combinato- rial irradiation is performed sequentially [45, 46]. We, therefore, conceived and constructed a radiation device that enables irradiation across the entire UVB, UVA, VIS, and nIR range and can also generate the individual wavelength bands as well as any combination therefrom. Importantly, whilst combinations have frequently been applied sequentially [47, 48], our radiation device is con- structed for simultaneous irradiation of all possible com- binations. Furthermore, this device has proven to be stable for the irradiation of conventional cultures as well as 3D organotypic cultures for both acute and chronic exposure. As an example, 3D skin equivalents were irradiated 3 times a week for as long as 10 weeks without changes in the radia- tion quality (Boukamp, Pavez Lorie personal communica- tion and [49]), thus making the presented irradiation device unique and demonstrating its broad scope of application. We here utilised this device to demonstrate biological effects following acute irradiation of HaCaT cells with 1712 Photochemical & Photobiological Sciences (2022) 21:1701–1717 1 3 all four individual spectral bands as well as all possi- ble combinations thereof, including the solar UV spec- trum (simultaneous UVB and UVA irradiation) as well as the entire spectrum (simultaneous irradiation with UVB + UVA + VIS + nIR). With this, we aimed to address the question of whether and how the different wavelengths would influence each other, respectively whether synergis- tic/additive or modulatory effects are seen with respect to different biological endpoints. As proof-of-principle, we investigated three basic biologi- cal principles, namely sensitivity towards radiation (toxicity measured by MTT test) and cell cycle regulation, as well as long-term growth (colony formation) upon radiation with the different wavelengths and combinations. So far, more complex comparative studies are rare. One corresponding work was recently performed utilising the Newport solar simulator and IR/VIS blocking filters to allow for irradiation with the entire solar spectrum versus the Fig. 6   Colony sizes in the clonogenic survival assay after irradia- tion with individual and combinations of spectral bands. A–C Indi- vidual spectral band exposures by UVB, UVA and nIR respectively. D–F Combinations of two spectral bands as indicated. G Full spec- trum irradiation. Displayed are the size distributions of the colonies obtained after exposure (grey boxes) together with the sham-irradi- ated controls (white boxes). The first control represents the unirradi- ated control that was kept in PBS for the same duration as the sec- ond irradiation dose (approximately 5 min) and was used as reference control for the first two exposures. Longer exposures were normalised to the time-matched sham-irradiated control. Each bar is the result of the pooled colonies obtained from at least 3 biological replicates. Boxes represent the 25th to 75th percentile and whiskers extend to the minimum and maximum. The solid line represents the median. Significance was tested for each group vs its corresponding control using one-way ANOVA test with Bonferroni post test using a signifi- cance level of 0.05. *p ≤ 0.05; **p ≤ 0.01; ***p ≤ 0.001 1713Photochemical & Photobiological Sciences (2022) 21:1701–1717 1 3 solar UV spectrum [24]. In this publication, Birch-Machin and coworkers investigated primary human keratinocytes and fibroblasts exposed to individual and combined irra- diation of the IR, VIS, and UV. ROS induction as well as mitochondrial and nuclear damage were studied [24]. They found a greater induction of these three endpoints with the solar spectrum radiation as compared to solar UV radiation alone (sUV). Interestingly, they even found a clear difference between epidermal keratinocytes and dermal fibroblasts, thereby demonstrating differences in response to differ- ent wavelengths combinations as well as differences in the response pattern of the two skin cell types, with fibroblasts being more affected than keratinocytes. Concerning our studies, measuring sensitivity to radia- tion by means of cellular metabolic activity (MTT test) was already informative. Whilst UVB showed significant dose- dependent toxicity, UVA exhibited an only minor toxic effect at higher doses. VIS and nIR did not confer toxicity. These findings are in line with previous reports showing that VIS (36 J/cm2) is non-toxic for HaCaT cells. Cytotoxic effects of VIS exposure are dependent on the presence of mela- nin, which is not found in HaCaT cells [40, 50], but other sensitizers might be involved as well, such as β-carotene, porphyrins or flavins [51]. With respect to the isolated nIR exposure, we did not find enhanced cell survival/metabolic activity as reported for high irradiance laser exposure of L929 mouse fibroblasts [52]. This might be due to the dif- ferent cell type used (fibroblasts versus epithelial cells), the power levels, and/or a specific wavelength effect. Accord- ingly, nIR-addition did not alter the toxicity profile when combined with UVB or UVA. However, simultaneous radiation with UVB and UVA either as sUV radiation or in combination with VIS and IR radiation, showed syner- gism, leading to clearly increased toxicity. Observed impair- ment of metabolic competence in irradiated cells may have resulted from oxidative stress, which is a self-propagating process. Therefore, initial oxidative damage, resulting from radiation-excited state of the cellular components or by pho- tosensitization, creates additional free radicals that damage mitochondria and consequently leads to further ROS pro- duction [53]. It was demonstrated for excised human skin that not only UVA and UVB radiations were responsible for the radical production during sun exposure, but also that up to 50% of the radicals were produced by the VIS/nIR radiation. Therefore, the synergetic effect of the entire spec- trum may result from activation of several ROS promoting pathways, with different chromophores and cell components being involved in free radical production elicited by solar spectrum wavelengths that finally enhance and promote each other (Fig. 3H). Regarding cell cycle regulation, in vitro studies have shown that UVB irradiation is capable of inducing a cell cycle arrest in G1 phase, thereby delaying S-phase [54, 55]. We find an early UVB-dependent G1 arrest (after 2–4 h) whilst this is missing upon UVA radiation. It was recently suggested that “a less-effective cell cycle arrest with UVA may render UVA-induced pyrimidine dimers more muta- genic than UVB-induced ones” [56]. As part of the solar spectrum, the role of UVA in cell cycle regulation may, however, be less clear. Our data suggest that within the entire solar spectrum, UVB is the foremost in cell cycle regulation whilst UVA does not seem to contribute exces- sively. In agreement with reports by others [56], we found UVA-related cell cycle effects at significantly higher doses, i.e. starting from 100 kJ/m2 (data not shown). This in turn indicates that in combination, the action profile of the indi- vidual wavelength is subject to modification and that for a realistic (human) risk assessment, the entire solar spectrum will prove to be the gold standard. It needs to be appreciated that the G1 arrest is predomi- nated by p53 and may not be as extensive in HaCaT cells that carry p53 mutations in both alleles of the p53 gene [57]. However, this detailed study demonstrates that UVB and to some extent also the entire solar spectrum is able to induce an early G1 arrest also in the HaCaT cells, supporting a role for a p53-independent mechanism in inducing a G1- to S-phase delay in p53-deficient keratinocytes [58]. These findings are in agreement with earlier reported cell cycle perturbation following UVB, considering the p53 status of the HaCaT cells [56, 59–61]. Of note, the UVB-dependent arrest seems to be suppressed when combined with UVA or nIR exposure but not when being part of the entire solar spectrum, demonstrating the importance of differential inter- active regulations. Twelve hours after UVB radiation, the cells experience a strong S-phase boost. Accumulation of S-phase cells was also described earlier, and in vivo studies support evidence for a mitogenic response of UVB irradiation [62]. In hairless mice (hr/hr), an increase in S-phase was observed as early as 12 h after treatment with a sub-erythema dose of 12.5 mJ per cm2 or an erythema dose of 25 mJ per cm2 [63, 64]. In line with this interpretation, UVB alone as well as all com- binations containing low-dose UVB (0.36 kJ/m2) favoured the development of large colonies indicative of an enhanced proliferation rate as also reported in [65]. Whilst nIR did not exhibit any obvious cell cycle regula- tion, UVA provoked a late (72 h) G1 arrest. Whereas domi- nant also in different combinations, this UVA-dependent G1 arrest was no longer effective when UVA was part of the entire solar spectrum demonstrating the more complex modulation when all wavelengths were combined. To investigate for more long-term effects, we additionally assayed for colony formation following the different radia- tion regimes. Again, the dominant dose-dependent toxic- ity of UVB was reflected in the cells’ ability to generate colonies. Our results for UVA and UVB reduced colony 1714 Photochemical & Photobiological Sciences (2022) 21:1701–1717 1 3 formation is in line with previously reported values, e.g. [66]. The UVB-related cytotoxicity also dominated any combination with other spectral components. Interestingly, the combination of UVB and nIR caused an even stronger dose-dependent decrease in the number of colonies, whilst in combination with UVA, the effect was reduced. Since the molecular mechanism underlying these phenotypes are still elusive, these findings once more demonstrate that, although on their own not affecting the investigated growth param- eters, in combination they can be of the modulatory effects for the cells. It is well known that the different wavelengths are absorbed by different chromophores; therefore, the final action spectrum is not a simple addition of the individual action spectra but an interplay of all four action spectra. Whilst the MTT test is a measure for toxicity, i.e. imme- diate cell death, the clonogenic or colony formation assay adds in determining the ability of single cells to expand into colonies, thereby test the cell’s regenerative capacity and with that the ability to maintain or even improve their pro- liferative potential. Accordingly, many studies performed with this assay have established extensive information on the sensitivity to, e.g. radiation or chemotherapeutics but also about recovering from such insults (number and size of the colonies). We now add, using this new radiation source, that UVB alone and in all combinations (UVA, nIR and VIS) is the most toxic wavelength (MTT test, colony number). It is, however, noteworthy that the colony size seems to increase upon low-dose UVB radiation either alone or as part of the entire solar spectrum. With higher doses and in a dose- dependent manner, a decline in colony size is induced. This fact points to a differential response and importantly applies for the entire solar spectrum, and may be of relevance for the radiation response in humans. Therefore, this low-dose UV effect will be further investigated. In conclusion, we here present a radiation device that besides the combined UVB, UVA, VIS and nIR (with an integrated irradiance distribution close to natural sunlight) allows for the irradiation with the individual spectra as well as any combination thereof. Thereby, it allows for the iden- tification of additive synergistic or even modulatory effects provided by the individual wavelengths as well as their com- binations thereof including that of the full spectrum (UVB to nIR) with the same device and thus with the same and directly comparable spectral distribution within the solar spectrum. Accordingly, we can show that cell death is pre- dominantly determined by UVB, though augmented in com- bination with UVA. Also, the cell cycle is most significantly affected by UVB exposure. Co-exposure with UVA or nIR exerts some modulation, which is lost when being part of the entire solar spectrum. Clonogenic activity that is mostly affected by UVB extend is suppressed by UVA and increased by nIR co-exposure. In the entire spectrum, the UVA and nIR effects are neutralised. Supplementary Information  The online version contains supplemen- tary material available at https://​doi.​org/​10.​1007/​s43630-​022-​00252-w. Acknowledgements  We would like to thank the group of Prof. Khanh, Technical University of Darmstadt (Laboratory of Adaptive Lighting Systems and Visual Processing) and Photometrik GmbH for technical support and input in the lamp development. We thank Anne Lehmkuhl for cell culture support. We would also like to thank the Workshop of the Department of Biology, Technical University of Darmstadt and Manuel Camargo for their support in building the irradiation device. Author contributions  All authors contributed to the study conception and design. Lamp design, construction and validation was done by NS, EP-L, IC, MP, JK, BV, RG, PB and AR. Biological experiments were conducted by BP-M, NS, EP-L, IC and AR. The manuscript was written by EP-L, BV, RG, PB and AR and approved by all authors. Funding  The study was supported by the Federal Ministry for Research and Education Germany (BMBF) through funding of the KAUVIR consortium (02NUK036). Open Access funding enabled and organized by Project DEAL. We acknowledge support by the Deutsche Forschun- gsgemeinschaft (DFG–German Research Foundation) and the Open Access Publishing Fund of Technical University of Darmstadt. Availability of data and material (data transparency)  All primary data are available from the TU datalib (https://​tudat​alib.​ulb.​tu-​darms​tadt.​ de/​handle/​tudat​alib/​1126). Code availability (software application or custom code)  Not applicable. Declarations  Conflict of interest  The design of the irradiation device is covered by a patent application (10 2022 102 915.8) filed at the Deutsches Pat- ent- und Markenamt (German Patent and Trade Mark Office) by the authors. Open Access  This article is licensed under a Creative Commons Attri- bution 4.0 International License, which permits use, sharing, adapta- tion, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://​creat​iveco​mmons.​org/​licen​ses/​by/4.​0/. References 1. de Assis, L. V. M., Tonolli, P. N., Moraes, M. N., Baptista, M. S., & de Lauro Castrucci, A. M. (2021). How does the skin sense sun light? An integrative view of light sensing molecules. Journal of Photochemistry and Photobiology C, 47, 100403. 2. Pearse, A. D., Gaskell, S. A., & Marks, R. (1987). Epidermal changes in human skin following irradiation with either UVB or UVA. The Journal of Investigative Dermatology, 88(1), 83–87. 3. Wischermann, K., Popp, S., Moshir, S., Scharfetter-Kochanek, K., Wlaschek, M., de Gruijl, F., Hartschuh, W., Greinert, R., Volkmer, https://doi.org/10.1007/s43630-022-00252-w https://tudatalib.ulb.tu-darmstadt.de/handle/tudatalib/1126 https://tudatalib.ulb.tu-darmstadt.de/handle/tudatalib/1126 http://creativecommons.org/licenses/by/4.0/ 1715Photochemical & Photobiological Sciences (2022) 21:1701–1717 1 3 B., Faust, A., Rapp, A., Schmezer, P., & Boukamp, P. (2008). UVA radiation causes DNA strand breaks, chromosomal aber- rations and tumorigenic transformation in HaCaT skin keratino- cytes. Oncogene, 27(31), 4269–4280. 4. Greinert, R., Detzler, E., & Harder, D. (2000). The kinetics of postirradiation chromatin restitution as revealed by chromosome aberrations detected by premature chromosome condensation and fluorescence in situ hybridization. Radiation Research, 154(1), 87–93. 5. Mitchell, D. L., Volkmer, B., Breitbart, E. W., Byrom, M., Low- ery, M. G., & Greinert, R. (2001). Identification of a non-dividing subpopulation of mouse and human epidermal cells exhibiting high levels of persistent ultraviolet photodamage. The Journal of Investigative Dermatology, 117(3), 590–595. 6. Rapp, A., & Greulich, K. O. (2004). After double-strand break induction by UV-A, homologous recombination and nonhomolo- gous end joining cooperate at the same DSB if both systems are available. Journal of Cell Science, 117(Pt 21), 4935–4945. 7. Yoon, J. H., Lee, C. S., O’Connor, T. R., Yasui, A., & Pfeifer, G. P. (2000). The DNA damage spectrum produced by simulated sunlight. Journal of Molecular Biology, 299(3), 681–693. 8. Arlett, C. F., Lowe, J. E., Harcourt, S. A., Waugh, A. P., Cole, J., Roza, L., Diffey, B. L., Mori, T., Nikaido, O., & Green, M. H. (1993). Hypersensitivity of human lymphocytes to UV-B and solar irradiation. Cancer Research, 53(3), 609–614. 9. Sayre, R. M., Cole, C., Billhimer, W., Stanfield, J., & Ley, R. D. (1990). Spectral comparison of solar simulators and sunlight. Photodermatology, Photoimmunology and Photomedicine, 7(4), 159–165. 10. Sayre, R. M., Stanfield, J., Bush, A. J., & Lott, D. L. (2001). Sun- screen standards tested with differently filtered solar simulators. Photodermatology, Photoimmunology and Photomedicine, 17(6), 278–283. 11. Marionnet, C., Tricaud, C., & Bernerd, F. (2014). Exposure to non-extreme solar UV daylight: Spectral characterization, effects on skin and photoprotection. International Journal of Molecular Sciences, 16(1), 68–90. 12. Colarossi, D., Tagliolini, E., Principi, P., & Fioretti, R. (2021). Design and validation of an adjustable large-scale solar simulator. Applied Sciences, 11(4), 1964. 13. Tawfik, M., Tonnellier, X., & Sansom, C. (2018). Light source selection for a solar simulator for thermal applications: A review. Renewable and Sustainable Energy Reviews, 90, 802–813. 14. López-Fraguas, E., Sánchez-Pena, J. M., & Vergaz, R. (2019). A Low-Cost LED-Based Solar Simulator. IEEE Transactions on Instrumentation and Measurement, 68, 4913–4923. 15. Kolberg, D., Schubert, F., Lontke, N., Zwigart, A., & Spinner, D. M. (2011). Development of tunable close match LED solar simulator with extended spectral range to UV and IR. Energy Procedia, 8, 100–105. 16. Godar, D., Miller, S., & Thomas, D. (1994). Immediate and delayed apoptotic cell death mechanisms: UVA versus UVB and UVC radiation. Cell Death and Differentiation, 1(1), 59–66. 17. De Gruijl, F. R. (2000). [33] Photocarcinogenesis: UVA vs UVB. Methods in Enzymology, 319, 359–366. 18. Zastrow, L., Groth, N., Klein, F., Kockott, D., Lademann, J., Renneberg, R., & Ferrero, L. (2009). The Missing Link – Light- Induced (280–1,600 nm) Free Radical Formation in Human Skin. Skin Pharmacology and Physiology, 22(1), 31–44. 19. Duteil, L., Cardot-Leccia, N., Queille-Roussel, C., Maubert, Y., Harmelin, Y., Boukari, F., Ambrosetti, D., Lacour, J.-P., & Pas- seron, T. (2014). Differences in visible light-induced pigmenta- tion according to wavelengths: A clinical and histological study in comparison with UVB exposure. Pigment Cell and Melanoma Research, 27(5), 822–826. 20. Sondenheimer, K., & Krutmann, J. (2018). Novel means for pho- toprotection. Frontiers in Medicine, 5, 162. 21. Menezes, S., Coulomb, B., Lebreton, C., & Dubertret, L. (1998). Non-coherent near infrared radiation protects normal human der- mal fibroblasts from solar ultraviolet toxicity. Journal of Investiga- tive Dermatology, 111(4), 629–633. 22. Diffey, B., & Osterwalder, U. (2017). Labelled sunscreen SPFs may overestimate protection in natural sunlight. Photochemical and Photobiological Sciences, 16(10), 1519–1523. 23. Grandi, C., & D’ovidio, M. C. (2020). Balance between health risks and benefits for outdoor workers exposed to solar radiation: An overview on the role of near infrared radiation alone and in combination with other solar spectral bands. International Journal of Environmental Research and Public Health, 17(4), 38–39. 24. Hudson, L., Rashdan, E., Bonn, C. A., Chavan, B., Rawlings, D., & Birch-Machin, M. A. (2020). Individual and combined effects of the infrared, visible, and ultraviolet light components of solar radiation on damage biomarkers in human skin cells. The FASEB Journal, 34(3), 3874–3883. 25. Zastrow, L., & Lademann, J. (2016). Light-Instead of uv protec- tion: New requirements for skin cancer prevention. Anticancer Research, 36(3), 1389–1394. 26. Sage, E., Lamolet, B., Brulay, E., Moustacchi, E., Chteauneuf, A., & Drobetsky, E. A. (1996). Mutagenic specificity of solar UV light in nucleotide excision repair-deficient rodent cells. Proceed- ings of the National Academy of Sciences of the United States of America, 93(1), 176–180. 27. Bustamante, M., Hernandez-Ferrer, C., Tewari, A., Sarria, Y., Harrison, G., Puigdecanet, E., Nonell, L., Kang, W., Friedländer, M., Estivill, X., González, J., Nieuwenhuijsen, M., & Young, A. (2020). Dose and time effects of solar-simulated ultraviolet radia- tion on the in vivo human skin transcriptome. The British Journal of Dermatology, 182(6), 1458–1468. 28. Cadet, J., & Wagner, J. (2013). DNA base damage by reactive oxygen species, oxidizing agents, and UV radiation. Cold Spring Harbor Perspectives in Biology. https://​doi.​org/​10.​1101/​CSHPE​ RSPECT.​A0125​59 29. Boukamp, P., Petrussevska, R. T., Breitkreutz, D., Hornung, J., Markham, A., & Fusenig, N. E. (1988). Normal keratinization in a spontaneously immortalized aneuploid human keratinocyte cell line. The Journal of Cell Biology, 106(3), 761–771. 30. Riss, T. L., Moravec, R. A., Niles A. L., Duellman, S., Benink, H. A., Worzella, T. J. & Minor, L. (2013). Cell viability assays. In: Markossian, G. S., Sittampalam, A., Grossman, K., Brimacombe, M., Arkin, D., Auld, C. P., Austin, J., Baell, J. M. M., Caaveiro, T. D. Y., Chung, N. P., Coussens, J. L., Dahlin, V., Devanaryan, T. L., Foley, M., Glicksman, M. D., Hall, J. V, Haas, S. R. J., Hoare, J., Inglese, P. W., Iversen, S. D., Kahl, S. C., Kales, S., Kirshner, M., Lal-Nag, Z., Li, J., McGee, O., McManus, T., Riss P., Sarad- jian, O. J., Trask Jr., J. R., Weidner, M. J., Wildey, M., Xia & Xu, X. (eds). Assay Guidance Manual. Bethesda (MD): Eli Lilly & Company and the National Center for Advancing Translational Sciences (2004). Available from: https://​www.​ncbi.​nlm.​nih.​gov/​ books/​NBK14​4065/. 31. ASTM (2020). Standard tables for reference solar spectral irra- diances: Direct normal and hemispherical on 37° tilted surface. https://​www.​astm.​org/​g0173-​03r20.​html. Accessed 23 March 2022. 32. McKenzie, R., Blumthaler, M., Diaz, S., Fioletov, V., Herman, J., Seckmeyer, G., Smedley, A., Webb, A. & New A (2014). Ration- alizing nomenclature for uv doses and effects on joint publica- tion of cie and wmo (World Meteorological Organization). CIE 209:2014, ISBN: 978-3-902842-35-0. 33. Kollias, N., Baqer, A. H., & Ou-Yang, H. (2003). Diurnal and seasonal variations of the UV cut-off wavelength and most https://doi.org/10.1101/CSHPERSPECT.A012559 https://doi.org/10.1101/CSHPERSPECT.A012559 https://www.ncbi.nlm.nih.gov/books/NBK144065/ https://www.ncbi.nlm.nih.gov/books/NBK144065/ https://www.astm.org/g0173-03r20.html 1716 Photochemical & Photobiological Sciences (2022) 21:1701–1717 1 3 erythemally effective wavelength of solar spectra. Photoderma- tology, Photoimmunology and Photomedicine, 19(2), 89–92. 34. Perdiz, D., Grof, P., Mezzina, M., Nikaido, O., Moustacchi, E., & Sage, E. (2000). Distribution and repair of bipyrimidine photo- products in solar UV-irradiated mammalian cells. Possible role of Dewar photoproducts in solar mutagenesis. Journal of Biological Chemistry, 275(35), 26732–26742. 35. Rochette, P. J., Therrien, J. P., Drouin, R., Perdiz, D., Bastien, N., Drobetsky, E. A., & Sage, E. (2003). UVA-induced cyclobutane pyrimidine dimers form predominantly at thymine-thymine dipy- rimidines and correlate with the mutation spectrum in rodent cells. Nucleic Acids Research, 31(11), 2786–2794. 36. Han, W., & He, Y. (2009). Requirement for metalloproteinase- dependent ERK and AKT activation in UVB-induced G1-S cell cycle progression of human keratinocytes. Photochemistry and Photobiology, 85(4), 997–1003. 37. Ikehata, H., & Ono, T. (2011). The mechanisms of UV mutagen- esis. Journal of Radiation Research, 52(2), 115–125. 38. Cohen, L., Brodsky, M. A., Zubair, R., Kohli, I., Hamzavi, I. H., & Sadeghpour, M. (2020). Cutaneous interaction with visible light: what do we know. Journal of the American Academy of Dermatol- ogy. https://​doi.​org/​10.​1016/J.​JAAD.​2020.​03.​115 39. Liebel, F., Kaur, S., Ruvolo, E., Kollias, N., & Southall, M. D. (2012). Irradiation of skin with visible light induces reactive oxy- gen species and matrix-degrading enzymes. Journal of Investiga- tive Dermatology, 132(7), 1901–1907. 40. Tonolli, P. N., Chiarelli-Neto, O., Santacruz-Perez, C., Junqueira, H. C., Watanabe, I. S., Ravagnani, F. G., Martins, W. K., & Bap- tista, M. S. (2017). Lipofuscin generated by UVA turns keratino- cytes photosensitive to visible light. The Journal of Investigative Dermatology, 137(11), 2447–2450. 41. Kim, S. J., Lee, H. J., Lee, J. H., Oh, H., Park, S., Lim, D. H., Park, M. S., & Lee, J. B. (2021). In vivo determination of the Infrared-A protection factor on human skin. Skin Research and Technology, 27(5), 814–823. 42. De Marais, T. L., Kluz, T., Xu, D., Zhang, X., Gesumaria, L., Matsui, M. S., Costa, M., & Sun, H. (2017). Transcription factors and stress response gene alterations in human keratinocytes fol- lowing Solar Simulated Ultra Violet Radiation. Scientific Reports, 7(1), 1–13. 43. Zhang, X., Kluz, T., Gesumaria, L., Matsui, M. S., Costa, M., & Sun, H. (2016). Solar simulated ultraviolet radiation induces global histone hypoacetylation in human keratinocytes. PLoS ONE, 11(2), e0150175. 44. Lohan, S., Vitt, K., Scholz, P., Keck, C., & Meinke, M. (2017). ROS production and glutathione response in keratinocytes after application of β-carotene and VIS/NIR irradiation. Chemico- biological Interactions, 28, 01–07. 45. Schieke, S., Ruwiedel, K., Gers-Barlag, H., Grether-Beck, S., & Krutmann, J. (2005). Molecular crosstalk of the ultraviolet a and ultraviolet B signaling responses at the level of mitogen-activated protein kinases. The Journal of Investigative Dermatology, 124(4), 857–859. 46. Krutmann, J. (2006). The interaction of UVA and UVB wavebands with particular emphasis on signalling. Progress in Biophysics and Molecular Biology, 92(1), 105–107. 47. Jantschitsch, C., Majewski, S., Maeda, A., Schwarz, T., & Schwarz, A. (2009). Infrared radiation confers resistance to uv- induced apoptosis via reduction of DNA damage and upregulation of antiapoptotic proteins. Journal of Investigative Dermatology, 129(5), 1271–1279. 48. Portantiolo-Lettnin, A., Teixeira Santos Figueiredo Salgado, M., Gonsalez Cruz, C., Manoel Rodrigues da Silva Júnior, F., Cunha Gonzalez, V., de Souza Votto, A., Santos Trindade, G., & de Moraes Vaz Batista Filgueira, D. (2016). Protective effect of infrared-A radiation against damage induced by UVB radiation in the melan-a cell line. Journal of Photochemistry and Photobiol- ogy B, 163, 125–132. 49. Worst, P. (2019). CsA is promoting tumor-like invasion in a long- term human skin equivalent. PhD thesis, Heinrich Heine Univer- sity Düsseldorf, Germany. https://​docse​rv.​uni-​duess​eldorf.​de/​servl​ ets/​Docum​entSe​rvlet?​id=​51883. 50. Chiarelli-Neto, O., Ferreira, A. S., Martins, W. K., Pavani, C., Severino, D., Faiao-Flores, F., Maria-Engler, S. S., Aliprandini, E., Martinez, G. R., Di Mascio, P., Medeiros, M. H., & Baptista, M. S. (2014). Melanin photosensitization and the effect of visible light on epithelial cells. PLoS ONE, 9(11), e113266. 51. Lawrence, K. P., Douki, T., Sarkany, R. P. E., Acker, S., Herzog, B., & Young, A. R. (2018). The UV/visible radiation boundary region (385–405 nm) damages skin cells and induces “Dark” cyclobutane pyrimidine dimers in human skin in vivo. Scientific Reports, 8(1), 1–12. 52. Solmaz, H., Ulgen, Y., & Gulsoy, M. (2017). Photobiomodulation of wound healing via visible and infrared laser irradiation. Lasers in Medical Science, 32(4), 903–910. 53. De Jager, T. L., Cockrell, A. E., & Du Plessis, S. S. (2017). Ultraviolet light induced generation of reactive oxygen species. Advances in Experimental Medicine and Biology, 99, 615–623. 54. Petrocelli, T., Poon, R., Drucker, D. J., Slingerland, J. M., & Rosen, C. F. (1996). UVB radiation induces p21Cip1/WAF1 and mediates G1 and S phase checkpoints. Oncogene, 12(7), 1387–1396. 55. Bånrud, H., Stokke, T., Moan, J., & Berg, K. (1995). S phase arrest and induction of multinucleated cells after exposure to ultra- violet radiation. Carcinogenesis, 16(5), 1087–1094. 56. Runger, T. M., Farahvash, B., Hatvani, Z., & Rees, A. (2012). Comparison of DNA damage responses following equimutagenic doses of UVA and UVB: A less effective cell cycle arrest with UVA may render UVA-induced pyrimidine dimers more muta- genic than UVB-induced ones. Photochemical and Photobiologi- cal Sciences, 11(1), 207–215. 57. Lehman, T. A., Modali, R., Boukamp, P., Stanek, J., Bennett, W. P., Welsh, J. A., Metcalf, R. A., Stampfer, M. R., Fusenig, N., & Rogan, E. M. (1993). p53 mutations in human immortalized epithelial cell lines. Carcinogenesis, 14(5), 833–839. 58. Geyer, R. K., Nagasawa, H., Little, J. B., & Maki, C. G. (2000). Role and regulation of p53 during an ultraviolet radiation-induced G1 cell cycle arrest. Cell Growth and Differentiation, 11(3), 149–156. 59. De Laat, A., Van Tilburg, M., Van Der Leun, J. C., Van Vloten, W. A., & De Gruijl, F. R. (1996). Cell cycle kinetics following UVA irradiation in comparison to UVB and UVC irradiation. Photo- chemistry and Photobiology, 63(4), 492–497. 60. Dixon, R. J., Eperon, I. C., Hall, L., & Samani, N. J. (2005). A genome-wide survey demonstrates widespread non-linear mRNA in expressed sequences from multiple species. Nucleic Acids Research, 33(18), 5904–5913. 61. Athar, M., Kim, A. L., Ahmad, N., Mukhtar, H., Gautier, J., & Bickers, D. R. (2000). Mechanism of ultraviolet B-induced cell cycle arrest in G2/M phase in immortalized skin keratinocytes with defective p53. Biochemical and Biophysical Research Com- munications, 277(1), 107–111. 62. Berton, T. R., Pavone, A., & Fischer, S. M. (2001). Ultraviolet- B irradiation alters the cell cycle machinery in murine epider- mis in vivo. The Journal of Investigative Dermatology, 117(5), 1171–1178. 63. Olsen, W. M., & Kirkhus, B. (1989). The epidermal cell kinetic response to ultraviolet B irradiation combines regenerative prolif- eration and carcinogen associated cell cycle delay. Photochemistry and Photobiology, 50(3), 391–397. 64. Olsen, W. M. (1988). Early cell kinetic effects of a single dose of monochromatic ultraviolet B irradiation on hairless mouse https://doi.org/10.1016/J.JAAD.2020.03.115 https://docserv.uni-duesseldorf.de/servlets/DocumentServlet?id=51883 https://docserv.uni-duesseldorf.de/servlets/DocumentServlet?id=51883 1717Photochemical & Photobiological Sciences (2022) 21:1701–1717 1 3 epidermis. The Journal of Investigative Dermatology, 91(6), 585–589. 65. Tyagi, N., Bhardwaj, A., Srivastava, S. K., Arora, S., Mari- muthu, S., Deshmukh, S. K., Singh, A. P., Carter, J. E., & Singh, S. (2015). Development and characterization of a novel in vitro progression model for UVB-induced skin carcinogenesis. Scien- tific Reports, 5(1), 1–11. 66. Hegedus, C., Boros, G., & Fidrus, E. (2020). PARP1 inhibition augments UVB-mediated. Cancers, 12(5), 1–29. Authors and Affiliations B. Plitta‑Michalak1,4 · N. Stricker1 · E. Pavez Loriè2,5 · I. Chen3 · M. Pollet2 · J. Krutmann2 · B. Volkmer3 · R. Greinert3 · P. Boukamp2 · A. Rapp1  1 Cell Biology and Epigenetics, Department of Biology, Technical University of Darmstadt, Schnittspahnstr. 10, 64287 Darmstadt, Germany 2 IUF-Leibniz Research Institute for Environmental Medicine, Auf’m Hennekamp 50, 40225 Düsseldorf, Germany 3 Centre of Dermatology, Elbe Clinics, Am Krankenhaus 1, 21614 Buxtehude, Germany 4 Present Address: Department of Chemistry, University of Warmia and Mazury in Olsztyn, Olsztyn, Poland 5 Present Address: Ludwig Boltzmann Institute for Traumatology, the Research Center in Cooperation with AUVA, Donaueschingenstraße 13, 1200 Vienna, Austria http://orcid.org/0000-0001-9108-3929 Development and characterisation of an irradiation device for biomedical studies covering the solar spectrum with individual regulated spectral bands Abstract Graphical abstract 1 Introduction 2 Materials and methods 2.1 Irradiation device 2.2 Cell culture 2.3 Irradiation 2.4 Flow-cytometric quantification of cyclobutane pyrimidine dimers (CPDs) 2.5 MTT assay 2.6 Cell cycle analysis 2.7 Colony formation assay 3 Results 3.1 Design and construction of a solar spectrum irradiator based on four separate lamps 3.2 Physical validation of the irradiation devices 3.3 Comparability and consistency of four versions of the irradiation devices: biological validation of the radiation efficacy 3.4 Cellular metabolic activity as measured by MTT 3.5 Cell cycle modulation of combined spectral bands 3.6 Clonogenic survival of UVB exposure is modulated by co-exposure with both UVA and nIR 3.7 Proliferative expansion (colony size) is influenced by UVB 4 Discussion Acknowledgements References